Following happened to me:
I crashed my kite and came closer to shore (sideonshore winds).
The kite tumbled around. The kite wanted to start in the power zone and in order to avoid getting dragged onto the beach I wanted to release the Iron Heart quick release...well, it didn't work! The red plastic didn't move at all, it was stuck.
Luckily I was able to unhook the chicken loop and the kite didn't power up in the power zone.
I also heard from a girl who had the same problem some days later.
I examined both Iron Hearts and found the problem.
To the right you see a burr (part that sticks out) which caused my IH to fail. It is sharp and pushing it with a certain angle it gets stucked in the red plastic.
Check both sides as shown on the picture for burrs.
If you have these, sand them with sand paper until it is smooth, then it will work properly.
If you have a burr, your Iron Heart will work if you push up the plastic straight up without any angle in the push. If you have a little pressure on the side of the red plastic, it gets stuck if you have a burr.
I informed North about the problem and they told me, they have in their manual an info under maintenance.
But North would also like to know, if more people had/have the problem.
So please reply if you have a burr too.
It looks like the metal part, that is at the end of the chicken loop and locked with the pin, works on the metal under pressure and causes the burr.
Thanks for your attention and cooperation.
Toby
was toch al eens eerder een probleem met die iron hearts?
svennie had een 2 sterren sessie in Oostvoorne autostrand met maar liefst 20 - 30 knots op zijn North Vegas (2011)
Ja, op de 2006. Dat is opgelost door gratis vervanging van loop met andere ring. Op een aantal trapeze's kon de ring van de loop in de haak van de trapeze blijven hangen.
Dit is ook makkelijk te fixen, maar op den duur wordt het belachelijk.
Ironheart gaat zowiezo moeilijk met zand, geeft hetzelfde effect. Busje met 14 mm uitboren en je hebt nergens meer last van. Deze "braam" ook even wegveijlen natuurlijk.